Appendix P - Phenol First Aid Guide and PPEAppendix P - Phenol First Aid Guide and PPE
Focus on Phenol First Aid and Personal Protective Equipment
Phenol is a common chemical used for activities such as tissue preservation and DNA/RNA extraction. Phenol can be a component in a commercial reagent (e.g. QIAzol, TRIzol) or prepared as part of a mixture in the laboratory (e.g. chloroform: phenol). Because phenol solutions are an integral part of routine life science applications, their hazards may be taken for granted. Make no mistake about it, however. Phenol can be very dangerous and the hazards are not just those of a typical corrosive.
The hazards of phenol are 2-fold. It is both a corrosive (can cause severe burns) and toxic (absorbed phenol acts as a systemic toxin). In one case, death resulted from ingestion of as little as 15 mL. Liquid phenol can penetrate the skin with efficiency approximately equal to that of inhalation. Deaths have been reported for exposures of 25% or more of body surface area. Phenol has an anesthetic effect and can cause severe burns that may not be immediately painful or visible. The threshold concentration of human skin damage from phenol is 1.5%. It can cause permanent eye injury, blindness and scarring.
Recommendations are that laboratories working with phenol use polyethylene glycol 300 or 400 (PEG-300 or PEG-400), rather than water, for immediate first aid treatment of dermal exposures. In addition, all laboratory groups using phenol should take the need for appropriate personal protective equipment (PPE) seriously and require its use as part of the laboratory operations when using phenol and documented in the Standard Operating Procedures (SOPs). This document can be added as a supplement to existing phenol SOPs.
SYMPTOMS OF PHENOL EXPOSURE
The most common route of occupational exposure for phenol is skin contact and absorption. Phenol does not readily form a vapor at room temperature and is unlikely to pose an inhalation hazard unless it is heated or misted. Additionally, it has a distinct, sweet, acrid, odor that is detected by most people at levels well below the OSHA airborne permissible exposure limit (PEL).
Phenol burns and intoxications can be life-threatening. Symptoms include:
- Eye Contact: Severe irritation, permanent damage, blindness.
- Inhalation: Respiratory irritation, sore throat, headache, and shortness of breath.
- Ingestion: Phenol is very toxic; death can occur rapidly following ingestion. Symptoms include irritation, swelling, burns and damage to the mouth, throat and stomach, internal bleeding, vomiting, diarrhea, decreased blood pressure, shock, collapse, coma and death.
- Skin Contact: Initial exposure can cause numbness or slight tingling, so contact may not be immediately apparent. However, even minor contact can result in burns, blisters, permanent skin damage. Absorption of phenol through skin can result in phenol toxicity with symptoms including muscle weakness, tremors, loss of coordination, shock, sudden collapse, coma, convulsions, organ damage and death. When phenol contacts the skin, a white covering of precipitated protein forms. It soon turns red and eventually sloughs off, leaving the surface stained slightly brown. If phenol is left on the skin, it will penetrate rapidly and lead to cell death and gangrene.
Exposure Control and Personal Protective Equipment
- Emergency Showers and Eyewashes: Any laboratory using phenol (or any corrosive/caustic chemical) must have an emergency eyewash station accessible within 10 seconds and located in the same room the hazard is being used. Emergency showers must be accessible within 10 seconds and can be located within the room or in the hallway.
- Administrative Controls: Never work alone when using phenol. Procedures requiring the use of phenol should have written safety SOPs associated with them, including the location of emergency equipment.
- Engineering Controls: Phenol must be used in a fume hood when working with stock solutions and making formulations and dilutions. Even when working with small amounts of dilute phenol, the best practice is to work in a fume hood because of the splash protection the sash provides and the ability of the hood to contain emissions especially in the event of a spill.
- Eye/Face Protection: Eye protection is required when working with phenol. Chemical splash goggles are best practice and a face shield (in addition to goggles) may also be necessary, depending on concentration and amount. Safety glasses can be worn if working with small quantities of phenol in a fume hood with the sash properly positioned to provide splash, spray and mist protection. Consider that small facial burns caused by splatter may not be life threatening but can result in permanent scarring/disfiguration
- Skin Protection: Lab coat, long sleeves, impervious full foot/closed toe shoes and long pants at a minimum. If body splash potential exists, wear a butyl rubber or neoprene apron.
- Hand Protection: Hand protection needs to be selected based on projected use (concentration and exposure). For working with phenol at concentrations >70%, butyl rubber, Viton, Barrier and Silver Shield gloves provide good resistance. Neoprene and polyvinyl alcohol are suitable for short term work (resistance to breakthrough within 1-4 hours) but should be thicker than 0.3 mm (11.8 mil).
- Thin disposable gloves are generally for splash protection only and should immediately be removed if phenol gets on them. Ansell recommends “NeoTouch®” (neoprene) or DermaShield (proprietary poly-chloroprene blend) for splash protection when working with 10% phenol solutions. A good practice is to use a heavy weight disposable (0.2 mm; 8 mil) and double glove. In general, nitrile is not recommended as a material of choice when working with phenol.
- Chloroform and Phenol Mixtures. Phenol is often used in combination with chloroform in nucleic acid purification procedures. Unfortunately, chloroform rapidly degrades both neoprene and nitrile. Ansell has recently developed a relative thin glove (ChemTek® 380214T) consisting of a 4 mil. outer layer of Viton® rubber over a 4 mil. layer of butyl rubber which provides >90 minutes breakthrough resistance to chloroform/phenol solutions. The request to develop this glove was initiated by the University of California, San Francisco as a result of a phenol/chloroform laboratory accident.
- The gloves demonstrated below (Viton Butyl) may be purchased from VWR, and although they are more expensive than nitrile, they may be reused after incidental contact (always inspect them before use and discard if holes are evident or contamination is apparent).
Eye: Rapid and immediate decontamination is critical. Flush with copious amounts of water using the emergency eyewash for at least 15 minutes, lifting eyelids occasionally. Remove contact lenses if easily removable without additional trauma to the eye. Do not interrupt flushing. Get medical attention immediately
- Inhalation: Remove to fresh air. Get medical attention immediately.
- Ingestion: Do not induce vomiting. If victim is conscious and able to swallow, give 4-8 oz (1 c) of milk or water. Get medical attention immediately. Never give anything by mouth to an unconscious person or while in the laboratory.
- Skin Contact: Rapid and immediate skin decontamination is critical to minimize phenol absorption. Anyone assisting the victim should wear protective clothing and gloves.
- Small Exposures. Rapidly remove contaminated clothing (including anything leather like belts or watchbands) and either irrigate or wipe exposed areas immediately and repeatedly with low-molecular-weight polyethylene glycol (PEG 300 or PEG 400). Treatment should be continued until there is no detectable odor of phenol. If PEG is not available, a gycerine solution can be used instead. If neither of these are available, irrigation with a source of high-density drenching water (such as an emergency shower) will reduce phenol uptake, but lesser amounts of water will merely dilute the phenol and expand the area of exposures. If using the shower or other, shower for at least 15 min.
- Large Exposures. First aid treatment is similar to that for small exposures except the amount of surface area to be decontaminated must be considered. If the amount of phenol on the skin is more than can be quickly removed by swabbing or irrigating with PEG, then an emergency shower should be used and 911 should be called immediately. A high-density shower is preferable to reduce phenol uptake. Lesser amounts of water will merely dilute the phenol and expand the area of exposure. If possible, use PEG after the initial decontamination. Otherwise, the victim should stay in the shower until the emergency responders arrive to provide assistance.
For any exposure, double-bag contaminated clothing and personal belongings. Get medical attention. Even if the exposure is small, it is still important to be evaluated by a medical professional to determine if follow-up treatment is necessary.
Phenol First Aid Kit
Laboratories that use phenol are advised to assemble a kit for first aid treatment of dermal exposure. The kit should be located in a visible area where the phenol work is being done (for instance, in the fume hood), or nearby with the location clearly posted. The principal investigator or laboratory manager should train all persons working with phenol on how to respond to a phenol exposure and how to use the kit.
EHS has designed a simple kit that can fit in a plastic zip-lock bag that laboratories can assemble themselves. Included in the kit is a 500 mL bottle of PEG 300 or PEG 400. Pharmaceutical grade (USP or NF) PEG is recommended and available from most chemical suppliers. A 500 mL bottle is meant to treat small areas of exposure, such as might occur when using DNA/RNA extraction kits. For work involving larger amounts of phenol, contact EHS for help designing a kit and a response plan suitable for the amount of phenol being used.
The recommended contents of the kit and instructions for use are listed below (the list of the contents of the kit can be taped to the outside of the large zip lock bag while the instructions for use should be kept in the bag). Date the bag with the expiration date of the PEG and replace the bottle when it expires (use the opportunity to inspect the integrity of the other items in the kit, such as gloves, and replace as necessary).
Phenol Skin (Dermal) Exposure First Aid Kit:
- Pre-packaged gauze pads, 4” x 4” (~10)
- Polyethylene Glycol 300 or 400, 500 mL (~ 1 pint) USP or NF
- Silver Shield gloves (1-2 pairs)
- Instructions for use
- Small plastic bag (for collecting waste gauze pads)
- Large plastic zip lock bag big enough to hold items above
Instructions Phenol Skin (Dermal) Exposure First Aid
Instructions Phenol Skin (Dermal) Exposure First Aid
Emergency Numbers: 911 (Ithaca campus phone and remote facilities)
(607) 255-1111 (Ithaca cell phone)
NOTE: This procedure is NOT for eye exposure. For eye exposure, flush with water in an eyewash station for at least 15 minutes and call 911 immediately.
Remove contaminated clothing, including any leather items such as watch bands or belts.
- Put on safety glasses and silver shield gloves (but don’t put on the gloves if you are treating yourself and your hands are contaminated with phenol).
- Open up a few packages of gauze pads.
- Pour polyethylene glycol liberally on to one of the gauze pads.
- Gently wipe off excessive phenol on exposed area. Discard the gauze pad in the small plastic bag in the kit.
- Take a new gauze pad, add polyethylene glycol, and continue to clean off exposed area. Discard the pad. Repeat with a new gauze pad and application of polyethylene glycol until all visible traces of phenol have been removed from the skin.
- Continue to gently wipe skin (do not scrape or irritate the effected skin area) with polyethylene glycol soaked gauze pads until no odor of phenol remains, changing the gauze pad frequently.
8. Even if you feel it is unnecessary to call 911 and get emergency help, please go for evaluation to determine if follow-up treatment is necessary. Don’t forget to fill out an on-line incident report! (Incident Reporting)
9. Double bag any contaminated clothing. Label both the bag and the small zip-lock bag for collecting the used gauze wipes as “Hazardous Waste – Phenol Contamination”. Contact EHS for proper disposal. (Waste Pickups)
10. Replace the contents of the kit with new, unused items
Monteiro-Riviere, N. A., A. O. Inman, H. Jackson, B. Dunn and S. Dimond. 2001. Efficacy of topical phenol decontamination strategies on severity of acute phenol chemical burns and dermal absorption: in vitro and in vivo studies in pig skin and Industrial Health. Toxicology and Industrial Health. 17:95-104
Ruth A Lawrence Poison and Drug Information Center (serving the Finger Lakes Region): 1-800-222-1222 (or 1-585-275-3232).
Phenol SOPPhenol SOP
Phenol is a common chemical used for activities such as tissue preservation and DNA/RNA extraction. Phenol can be a component in a commercial reagent (e.g. QIAzol, TRIzol) or prepared as part of a mixture in the laboratory (e.g. chloroform: phenol). It is both a corrosive and toxic. Phenol has an anesthetic effect and can cause severe burns that may not be immediately painful or visible. It can cause permanent eye injury and blindness. The NIOSH Recommended Exposure Level for Phenol is 5 ppm.
2. SPECIFIC HAZARD CLASSIFICATIONS (this section is not a substitution for the review of the Safety Data Sheet - SDS)
|P201||Obtain special instructions before use.|
|P260||Do not breathe dust/fume.|
|P270||Do not eat, drink or smoke when using this product.|
|P271||Use only outdoors or in a well-ventilated area.|
|P280||Wear protective gloves/protective clothing/eye protection/face protection.|
|P281||Use personal protective equipment as required.|
|P273||Avoid release to the environment.|
|P301+P310||If Swallowed: Immediately call a Poison Center or doctor/physician.|
|P301+P330+P331||If Swallowed: Rinse mouth. Do Not induce vomiting.|
|P303+P361+P353||If On Skin (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin with water/shower.|
|P305+P351+P338||If In Eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing.|
|P308+P313||If exposed or concerned: Get medical advice/attention.|
|P321||Specific treatment (see advice on this label).|
|P322||Specific measures (see advice on this label).|
|P363||Wash contaminated clothing before reuse.|
|P302+P352||If On Skin: Wash with plenty of water.|
|P304+P340||If Inhaled: Remove victim to fresh air and keep it at rest in a position comfortable for breathing.|
- EHS 2555 Laboratory Safety training
- EHS 2716 Chemical Waste Disposal Training
- EHS 2394 Cleaning Up Small Lab Spills
- Lab Specific – including SDS and SOP review with proficiency on procedure (include where this will be documented in the lab this can be a sign-off attached to the SOP)
4. Ordering OF Phenol and First Aid materials
Company, Catalogue number.
5. Storage and Use
- of reagent in the lab.
- of First Aid Kit
- of Spill Kit
Must be used in a fume hood.
6. Personal Protective Equipment (PPE)
See attached EHS Guidance Document: “Phenol First Aid and PPE”
7. Preparation of Solutions and Working Protocols
Research protocol specifics:
Describe how the samples will be transported to other buildings/rooms.
9. Waste Handling and Disposal
Phenol must be disposed of as hazardous waste – corrosive, toxic
Describe lab-specific process for labeling, storage and removal of hazardous waste.
For light contamination of small areas or items flush with plenty of water and wash items with soap or detergent and water.
Describe your clean up procedures to ensure there is no residue or transfer outside of the hood
- Secure and ventilate the area.
- For small spills wear appropriate PPE retrieve the spill kit from ______________.
- Absorb spill with a spill pad, absorbent material, or lab wipes. Bag spill cleanup materials in plastic bag and manage as hazardous waste.
- For larger spills e.g. over 500mL or if uncomfortable cleaning up:
- Ithaca: Use Emergency Phone or 607-255-1111 for EHS Spill Response. Include location of closest emergency equipment (safety showers, eyewashes, spill kit, First Aid guidance, etc.)
- Geneva specific procedures: call 911
ii. Personnel contamination or exposure: See the EHS Guidance Document: “Phenol First Aid Guide and PPE”
iii Complete incident report for any spill, injury, illness or exposure related to work at Cornell within 24 hours: Incident Reporting.